Suzhou Electric Appliance Research Institute
期刊號： CN32-1800/TM| ISSN1007-3175

Article retrieval

文章檢索

首頁 >> 文章檢索 >> 往年索引

均勻直流電場下變壓器油中金屬微粒聚集特性研究

來源：電工電氣發布時間：2022-08-29 09:29 瀏覽次數：453

均勻直流電場下變壓器油中金屬微粒聚集特性研究

邱虎1，2，楊旭1，2，羅傳仙1，2，張靜1，2，文豪1，2
(1 南瑞集團(國網電力科學研究院)有限公司，江蘇 南京 211106；
2 國網電力科學研究院武漢南瑞有限責任公司，湖北 武漢 430074)
 
    摘 要：金屬微粒在變壓器油道內部出現匯聚或堆積，由于其強導電性，會大大縮短油隙的絕緣有效距離，引發局部放電甚至絕緣擊穿。利用變壓器油中金屬微粒運動觀測平臺試驗裝置和高速相機捕獲不同外施電壓幅值下金屬微粒在橢圓形平板電極間的聚集過程，試驗結果表明：當外施電壓為 10 kV 和 20 kV 時，電極間金屬微粒濃度隨電壓施加時間逐漸降低，變壓器油中無法形成金屬微粒“小橋”，而當電壓升高至 30 kV 后，金屬微粒“小橋”將在平板電極邊緣出現；對油中微粒進行受力分析，發現微粒在電場邊緣所受電場梯度力可高達重力的 6 倍，微粒會在電場梯度力的作用下向電極邊緣運動，從而聚集形成金屬微粒“小橋”，最終引發絕緣擊穿。
    關鍵詞： 變壓器油；直流電壓；金屬微粒；聚集特性
    中圖分類號：TM406 ；TM855     文獻標識碼：B     文章編號：1007-3175(2022)08-0058-05
 
Research on Clustering of Metal Particle Accumulation Characteristic in
Transformer Oil Under Uniform DC Electric Field
 
QIU Hu1,2, YANG Xu1,2, LUO Chuan-xian1,2, ZHANG Jing1,2, WEN Hao1,2
（1 Nanjing NARI Group Corporation(State Grid Electric Power Research Institute), Nanjing 211106, China;
2 Wuhan NARI Limited Liability Company of State Grid Electric Power Research Institute, Wuhan 430074, China）
 
    Abstract: The metal particle could gather and accumulate inside the transformer oil tunnel. It has strong conductivity and could help shorten the effective insulation distance, trigger partial discharge, and initiate insulation breakdown. This research captured the gathering process of metal particles among oval plate electrodes under various voltage amplitude of the applied voltage by using an observation platform experimental setup of the metal particle movement in the transformer oil and high-speed camera. The metal particle consistency among the electrodes decreased with application time when the applied voltage was 10 kV and 20 kV, and the metal particle bridge could not be formed in transformer oil. When the voltage is up to 30 kV, and the metal particle bridge would emerge around rim of the plate electrodes. In addition,this paper analyzed the particles in the oil. It found that the electrical gradient force on particles is six times higher than gravity. Particles would move to the electrodes under the electrical gradient force,gathering as a bridge and triggering the insulation breakdown.
    Key words: transformer oil; DC voltage; metal particle; accumulation characteristic
 
參考文獻
[1] 王慧玲，楊俊哲. 我國特高壓直流輸電發展規劃與研究成果[J]. 中國機械，2014(23) ：34-35.
[2] 賈立雄，蔣錦峰，胡小正.2003 年度全國高壓直流輸電系統運行可靠性分析[J] . 電力設備，2004，5(11)：70-75.
[3] 李旭東. 交直流復合電壓下油紙絕緣沿面局部放電特性與電老化失效模型研究[D]. 重慶：重慶大學， 2018.
[4] MAHMUD S, CHEN G, GOLOSNOY I O, et al. Experimental Studies of Influence of DC and AC Electric Fields on Bridging in Contaminated Transformer Oil[J].IEEE Transactions on Dielectrics and Electrical Insulation， 2015， 22(1) ：152-160.
[5] TANG J, MA S, ZHANG M, et al.Influence of microbubbles motion state on partial discharge in transformer oil [J].IEEE Transactions on Dielectrics and Electrical Insulation，2015，22(5) ：2646-2652.
[6] 趙濤. 氣泡和纖維素顆粒對變壓器油沖擊擊穿特性影響研究[D]. 北京：華北電力大學，2017.
[7] 李清，楊東凱. 變壓器油中機械雜質顆粒分布情況試驗研究[J]. 華中電力，1999，12(1)：27-28.
[8] 王永紅. 換流變壓器油紙絕緣擊穿特性[D] . 哈爾濱：哈爾濱理工大學，2013.
[9] CHOI C, YATSUZUKA K, ASANO K.Dynamic motion of a conductive particle in viscous fluid under DC electric field[J].IEEE Transactions on Industry Applications，2001，37(3)：785-791.
[10] 王有元，李熙，李原龍，等. 交直流復合電壓下銅顆粒在油中的分布及對絕緣油擊穿特性的影響[J].電工技術學報，2018，33(23)：195-204.
[11] 李原龍. 固體顆粒在絕緣油中的運動特性及對絕緣油擊穿強度的影響[D]. 重慶：重慶大學，2017.